Trip to Phx, AZ to test the repairs

Living the #CopCarLife
In Phoenix, AZ outside the @TreehouseBakery
After all the repairs, this 300+ mile road trip (road test) went well , no issues, no leaks

Brakes & the gas leak are the next project

Rear End Leak

I saw a new leak on the concrete. So I jacked up the rear end to take a look

It was the passenger side wheel bearing again, leaking all over the wheel. (See video)

So I got new (better) bearings & seals and bought / loaned the tools for the job at the auto parts place

Bought new jack stands, and borrowed a good floor jack

So i was able to raise the rear end pretty high, a lot easier to work on here than it as the last time around a year ago when we had to do this job on the way home from Vegas in a friend’s dad’s garage

Had to pick a 94+ degree day to work on it, LOL

One side is in the shade, one side is not..


You can see the channel on the passenger side axle (right) from the bad bearings

Parts list:

  • RTV Blue
  • three quarts of 80W90 gear oil (Valvoline synthetic 75W-140) ?
  • outer bearings & seals


I hope I dont need this video

Continue reading

New headlights

New headlights !! Only took 10 minutes start to finish, lights cost less than $50 shipped

Wow, big difference at night

Clean or replace your headlights!! I think these are 2/3 brighter from inside.. wow

Now I need to aim them.. any theroys how to set up #CopCar headlights?

Leaking Oil Gasket

Went to change oil, and the guys saw a lot of oil leaking, so they filled it up and sent me to repair it. I grabbed a set of hoses and the new gasket and jacked up the car.

Not many videos o the process since it is so tedious to get to, but Ii managed to figure out the removal and replacement of the gasket

I did manage to break the bolt that holds the oil cooler hoses, so i had to drill it out and replace the 9mm/10mm bolt

Replaced the oil filter & changed oil too

In the end, the repair ent ell, and has remained fixed, money saved

Stopping Seat Belt Noise in Cop Car

Published on Aug 26, 2016

FOund out I could turn off the seat-belt noise in the Cop Car

Turn on key (dont start engine)
Wait for seat belt light to go off
Then click & UnClick the seat belt 3 times
Next turn the headlights on and off
Then click & UnClick the seat belt 3 more times
Watch the seat belt light go off
then click and unclick one more time
the seat belt light will flash 7 times to confirm

Find us on Facebook:

Find us on Twitter:!/GunWebsites


Differential Manual



2016 SHOT Show

This was a great year at the SHOT show. Our 11th year attending as media, but  the first year we were able to bring the dog. The drive up was great and un-eventfull20160117_162243Las Vegas is always a fun place to visit

Good parking this year

The car started to leak some fluid from the rear driver side wheel


So, after the show, I decided to fill the differential at a local shop ($7 cost of fluid is all they charged)
and see how bad the leak did on the way home

The car only got a few hundred miles (to Kingman, AZ)
Used the AAA 200-mile tow to get the car down to Phoenix, to a friends driveway


We stayed in a Walmart parking lot overnight, and started the day at the local auto parts store


Rented the tools to replace the rear axle seal.
And did the repair in a friends driveway in Phoenix, AZ


Turned out to be an in-expensive fix, (under $10 in parts)


Flat Tire

Got to change the tire on the side of the road today.
All things concidered it was an easy fix.. and now to fix or repair…20140507_18240320140515_094031 20140507_182408

Always carry a Full Size Spare

Had a flat tire today, but swapped it out in no time. It was a nice day, plenty of light. I pulled off Ina and had a lot of room too.


I carry a full size spare tire and a floor jack. So repair (or replacing) the damaged one doesn’t have to be done immediately


I try to buy surplus cop tires, but these are a chain-store brand20140515_094031

First Push Bars

Couldnt wait to get the Bumper Guard in place


Needed to take off all the trim, and attach the supports to the frame, then replace the white trim. The push bar attaches to those bases



IMAG1951The first bar I had (from craigs list) was not the correct one, and looked weird on the Crown Vic


FREE Inspection at Perfection Auto Works


Took the new cop car to Perfection Auto Works for the FREE Inspection they offer on Liberty Watch Radio on KVOI

Good to have the bumper to bumper inspection done by competent mechanics. They gave me a list of points and where the cop car stood

Thanks to Mike and the crew for the greak work, service and information